Assessing the environmental performance of vermicompost from spent coffee grounds based on a life cycle approach

• Bhanupong Phrommarat * Email ORCID ¹
• Pongsri Paopuree ORCID ²

1. Program in Biology, Faculty of Education, Chiang Rai Rajabhat University, Chiang Rai, Thailand
2. Department of Environmental Science, Faculty of Science, Silpakorn University, Nakhon Pathom, Thailand

Abstract

Purpose: This study investigated the physicochemical properties of vermicompost from spent coffee grounds (SCG) and assessed its environmental performance using Life Cycle Assessment (LCA). Additionally, the environmental performance of vermicompost was compared to other waste treatment and utilization scenarios.

Method: Two treatments of compost and vermicompost were produced from SCG and solid cow manure (SCM) with three replicates per treatment. Eudrillus eugeniae earthworms were used for vermicomposting. The physicochemical characteristics measured included pH, EC, TOM, TOC, TKN, TP, and TK. Statistical analysis was conducted using mean, SD, ANOVA, and Tukey’s test. The comparison of the environmental performance of vermicompost and alternative scenarios (compost from SCG and SCM, SCG as soil amendment, and SCG as waste) was assessed through LCA.

Results: Compost and vermicompost contained higher macronutrient contents than SCG. The LCA results revealed that vermicompost produced from SCG and SCM had significant environmental benefits by reducing the reliance on mineral N fertilizers and fishmeal in animal feed production, a 116% reduction in GWP100 compared with disposing in a landfill. A scenario analysis highlighted that disposing of SCG in a landfill had the highest impact on GWP100, while the baseline scenario demonstrated the most notable environmental benefit. In contrast, the baseline scenario exhibited the highest impact on EP, primarily due to NH₃ emissions resulting from organic fertilizers. This underscores the need for effective management practices to mitigate the contribution of NH₃ to eutrophication.

Conclusion: Vermicomposting showed significant potential in reducing organic waste, specifically SCG. According to LCA, it displayed a relatively low environmental impact across various impact categories, primarily due to the substitution of N fertilizers and fish meal.

Highlights

• Vermicompost from SCG and SCM is considered a nutrient-rich fertilizer.
• Life cycle assessment results show that vermicompost from SCG and SCM can reduce greenhouse gas emissions by 116% compared with other waste treatment scenarios.
• Significant reduction of reliance on chemical fertilizers and fishmeal in animal feed, leads to a massive reduction in greenhouse gas emissions.
• Vermicompost can cause ammonia emissions linked to water pollution.
• Effective management practices are needed to minimize ammonia emissions and maximize the environmental benefits of this sustainable solution.

References

Basosi R, Spinelli D, Fierro A, Jez S (2014) Mineral nitrogen fertilizers: environmental impact of production and use. In: Fertilizers: components, uses in agriculture and environmental impacts. NOVA Publishers, New York, pp 3-43.

Battista F, Barampouti EM, Mai S, Bolzonella D, Malamis D, Moustakas K, Loizidou M (2020) Added-value molecules recovery and biofuels production from spent coffee grounds. Renew Sustain Energy Rev 131:110007. https://doi.org/10.1016/j.rser.2020.110007

Boldrin A, Andersen JK, Møller J, Christensen TH (2009) Composting and compost utilization: accounting of greenhouse gases and global warming contributions. Waste Manag Res 27:800-812. https://doi.org/10.1177/0734242X09345275

Bomfim ASCd, de Oliveira DM, Walling E, Babin A, Hersant G, Vaneeckhaute C, Dumont MJ, Rodrigue D (2023) Spent Coffee Grounds Characterization and Reuse in Composting and Soil Amendment. Waste 1:2-20. https://doi.org/10.3390/waste1010002

Bong CPC, Lim LY, Ho WS, Lim JS, Klemeš JJ, Towprayoon S, Ho CS, Lee CT (2017) A review on the global warming potential of cleaner composting and mitigation strategies. J Clean Prod 146:149–157. https://doi.org/10.1016/j.jclepro.2016.07.066

Brontowiyono W, Rudiansyah M, Mahmudiono T, Shichiyakh RA, Iswanto AH, Abdulkadhim AH, Hussein SA, Yasin G, Sharma S, Aravindhan S (2022) Optimal preparation time in the vermicompost production process. Food Sci Technol 42:e03622. https://doi.org/10.1590/fst.03622

Cervera-Mata A, Molinero-García A, Martín-García J (2023) Sequential effects of spent coffee grounds on soil physical properties. Soil Use Manag 39(1):286-297. https://doi.org/10.1111/sum.12853 

Champar-ngam N, Iwai CB, Ta-oun M, Seripong S (2013) The change of phosphorus form in vermicompost using cassava pulp. Int J Environ Rural Dev 4(1):81-87. https://doi.org/10.32115/ijerd.4.1_81

Chen YC, Chen LY (2021) Pelleting spent coffee grounds by waste utensils as binders of biofuels. J Environ Chem Eng 9(3):105006. https://doi.org/10.1016/j.jece.2020.105006

Emmanuel SA, Yoo J, Kim EJ, Chang JS, Park YI, Koh SC (2017) Development of functional composts using spent coffee grounds, poultry manure and biochar through microbial bioaugmentation. J Environ Sci Health 52(11):802–811. https://doi:10.1080/03601234.2017.1356165

Favoino E, Hogg D (2008) The potential role of compost in reducing greenhouse gases. Waste Manag Res 26(1):61-69. https://doi.org/10.1177/0734242X08088584

Filipović A, Mandić A, Hadžiabulić A, Johanis H, Stipanović A, Brekalo H (2023) Characterization and evaluation of vermicomposting materials. Ekológia (Bratislava) 42(2):101-107. https://doi.org/10.2478/eko-2023-0012

Florio C, Fiorentino G, Corcelli F, Ulgiati S, Dumontet S, Güsewell J, Eltrop L (2019) A life cycle assessment of biomethane production from waste feedstock through different upgrading technologies. Energies 12(4):718. https://doi.org/10.3390/en12040718

Franca AS, Oliveira S (2022) Potential uses of spent coffee grounds in the food industry. Foods 11:2064. https://doi.org/10.3390/foods11142064

González-Moreno MA, García GB, Marcelino SS, Zaratiegui UJ, Robles DE, Pérez EMA, Seco MA (2020) Feasibility of Vermicomposting of Spent Coffee Grounds and Silverskin from Coffee Industries: A Laboratory Study. Agronomy 10(8):1125. https://doi.org/10.3390/agronomy10081125

Hafner SD, Pacholski A, Bittman S, Carozzi M, Chantigny M, Génermont S, et al (2019) A flexible semi-empirical model for estimating ammonia volatilization from field-applied slurry. Atmos Environ 199:474–484. https://doi:10.1016/j.atmosenv.2018.11.034

Hagemann N, Spokas K, Schmidt HP, Kägi R, Böhler MA, Bucheli TD (2018) Activated carbon, biochar and charcoal: linkages and synergies across pyrogenic carbon’s ABCs. Water 10(2):182. https://doi:10.3390/W10020182

Hanc A, Hrebeckova T, Grasserova A, Cajthaml T (2021) Conversion of spent coffee grounds into vermicompost. Bioresour Technol 341:125925. https://doi.org/10.1016/j.biortech.2021.125925

Hirooka Y, Kurashige S, Yamane K, Watanabe Y, Kakiuchi M, Ishikawa D, Miyagawa T, Iwai K, Iijima M (2021) Effectiveness of direct application of top dressing with spent coffee grounds for soil improvement and weed control in wheat-soybean double cropping system. Plant Prod Sci 25:148–156. https://doi.org/10.1080/1343943X.2021.2007142

Horwitz W (2000) Official methods of analysis of AOAC international, 17^th edn. Association of Official Analytical Chemistry International, Maryland.

Horwitz W, Latimer GW (2005) Official methods of analysis of AOAC international, 18th edn. Association of Official Analytical Chemistry International, Maryland.

IFA (2009) Energy efficiency and CO₂ emissions in ammonia production 2008-2009 summary report. International Fertilizer Association, Paris.

Johnson K, Liu Y, Lu M (2022) A review of recent advances in spent coffee ground up cycle technologies and practices. Front Chem Eng 4:838605. https://doi.org/10.3389/fceng.2022.838605

Keng ZX, Chong S, Ng CG, Ridzuan NI, Hanson S, Pan G-T, Lau PL, Supramaniam CV, Singh A, Chin CF (2020) Community-scale composting for food waste: A life-cycle assessment-supported case study. J Clean Prod 261:121220. https://doi.org/10.1016/j.jclepro.2020.121220

Komakech AJ, Zurbrügg C, Miito GJ, Wanyama J, Vinnerås B (2016) Environmental impact from vermicomposting of organic waste in Kampala, Uganda. J Environ Manage 181:395-402. https://doi.org/10.1016/j.jenvman.2016.06.028

Li L, Wu T, Li Y, Hu X, Wang Z, Liu J, Qin W, Ashraf U (2022) Deep fertilization improves rice productivity and reduces ammonia emissions from rice fields in China; a meta-analysis. Field Crops Res 289:108704. https://doi.org/10.1016/j.fcr.2022.108704

Lirikum, Kakati LN, Thyug L, Mozhui L (2022) Vermicomposting: an eco-friendly approach for waste management and nutrient enhancement. Trop Ecol 63:325–337. https://doi.org/10.1007/s42965-021-00212-y

Low JH, Rahman WAWA, Jamaluddin J (2015) The influence of extraction parameters on spent coffee grounds as a renewable tannin source. J Clean Prod 101:222-228. https://doi.org/10.1016/j.jclepro.2015.03.094

Manaf L, Jusho M, Yusoff M, Ismail TT, Harun R, Juahir H, Jusoff K (2009) Influences of bedding material in vermicomposting process. Int J Biol 1(1):81-91. https://doi.org/10.5539/ijb.v1n1p81

Musyoka MW, Adamtey N, Bünemann EK, Muriuki AW, Karanja EN, Mucheru-Muna M, Fiaboe KKM, Cadisch G (2019) Nitrogen release and synchrony in organic and conventional farming systems of the central highland of Kenya. Nutr Cycl Agroecosyst 113:283-305. https://doi.org/10.1007/s10705-019-09978-z

Nelson DW, Sommers LE (1996) Total carbon, organic carbon, and organic matter. In: Page et al (ed) Methods of Soil Analysis, Part 2, 2nd edn. Am Soc of Agron Inc, Madison, Wisconsin, pp 961-1010.

Oliveira LSBL, Oliveira DSBL, Bezerra BS, Pereira BS, Battistelle RAG (2017) Environmental analysis of organic waste treatment focusing on composting scenarios. J Clean Prod 155:229–237. https://doi.org/10.1016/j.jclepro.2016.08.093

Saha N, Chattrejee P, Sharma A, Metiya G, Halder M, Mukherjee D (2010) Vermicomposting influences phosphorus microbiology leading to phosphorus enrichment in end product. Int J Glob Environ 10(3-4):310-326. https://doi.org/10.1504/IJGENVI.2010.037273 

Shinde AM, Dikshit AK, Odlare M, Thorin E, Schwede S (2021) Life cycle assessment of bio-methane and biogas-based electricity production from organic waste for utilization as a vehicle fuel. Clean Technol Environ Policy 23:1715-1725. https://doi.org/10.1007/s10098-021-02054-7 

Singh V, Wyatt J, Zoungrana A, Yuan Q (2022) Evaluation of vermicompost produced by using post-consumer cotton textile as carbon source. Recycling 7:10. https://doi.org/10.3390/recycling7010010

Thongkheaw M (2010) The determination of protein and certain essential elements in earthworm Eudrilus eugeniae fed with different kinds of organic litters. Thesis, Suranaree University of Technology, Thailand

Ti C, Xia L, Chang SX, Yan XY (2019) Potential for mitigating global agricultural ammonia emission: A meta-analysis. Environ Pollut 245:141-148. https://doi.org/10.1016/j.envpol.2018.10.124

Udvardi M, Brodie EL, Riley W, Kaeppler S, Lynch J (2015) Impacts of agricultural nitrogen on the environment and strategies to reduce these impacts. Procedia Environ Sci 29:303. https://doi.org/10.1016/j.proenv.2015.07.275

Van der Stelt B, Temminghoff EJM, Van Vliet PCJ, Van Riemdijk WH (2007) Volatilization of ammonia from manure as affected by manure additives, temperature and mixing. Bioresour Technol 98:3449-3455. https://doi.org/10.1016/j.biortech.2006.11.004

Van der Stelt B, Van Vliet PCJ, Reijs JW, Temminghoff EJM, Van Riemsdijk WH (2008) Effect of dietary protein and energy levels on cow manure excretion and ammonia volatilization. J Dairy Sci 91(12):4811-4821. https://doi.org/10.3168/jds.2006-449

Vardon DR, Moser BR, Zheng W, Witkin K, Evangelista RL, Strathmann TJ, Rajagopalan K, Sharma BK (2013) Complete utilization of spent coffee grounds to produce biodiesel, bio-oil, and biochar. ACS Sustainable Chem Eng 1(10):1286-1294. https://doi.org/10.1021/SC400145W  

Walkley AJ, Black IA (1934) Estimation of soil organic carbon by the chromic acid titration method. Soil Sci 37:29-38.

Zampori L, Pant R (2019) Suggestions for updating the Product Environmental Footprint (PEF) method. Publications Office of the European Union, Luxembourg.